quarry dust as replacement of sand

clear picture that quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today

Aug 01, 2017 Aug 01, 2017 The replacement of natural fine aggregate by using quarry dust leads to consumption of generated quarry dust, the requirement of land fill area can be reduced and solves the natural sand scarcity problem. The sand availability as a fine aggregate at low cost which needs the reason to search as a alternative material

Ilangovan and Nagamani [18,19] reported that Natural Sand with Quarry Dust as full replacement in concrete as possible with proper treatment of Quarry Dust before utilization. The utilization of

River sand is most commonly used fine aggregate in concrete but due to acute shortage in many areas, availability, cost & environmental impact are the major concern (Ahmed et.al., 1989). To overcome from this crisis, partial replacement of sand with quarry dust can be an economic alternative

The optimum replacement level of SD as fine aggregates was 40% [2].One of the waste materials such as quarry dust used as a good alternative for sand in mixtures which gives more strength at 50%

partial replacement of sand by Quarry dust by 20%, 30%, 40% and 50%. The compressive strength of concrete cubes are obtained after 7 and 28 days of curing. This experimental study shows that the concrete made with quarry dust might not be as workable as normal concrete but it gives higher strength than the conventional concrete

May 19, 2020 QUARRY DUST AS FINE AGGREGATE: EFFECT ON COMPRESSIVE STRENGTH , DURABILITY AND WORKABILITY OF CONCRETE. The experimental study done by R Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao.[6] in which replacement of the sand with quarry dust shows an improvement in the compressive strength of the concrete

Jul 28, 2016 The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and

The complete replacement of sand with quarry dust gives the better results in terms of compressive strength studies. 3. TEST ON QUARRY DUST Silica, SiO. 2, is a colorless crystalline compound found mainly as sand, quartz, flint, and many other minerals. Silica is an important element to manufacture to enhance the strength property in

quarry dust), M 4 (40% quarry dust), M 5 (50% quarry dust) respectively. The variations of slump value with quarry dust percentage are shown in Figureure 1. It is observed that the slump value increases with increase in percentage replacement of sand with quarry dust for the same w/c ratio. Concrete does not give adequate

Nov 22, 2019 This paper report the experimental study which investigated the influence of 100% replacement of sand with quarry dust. Samples of concrete (cubes and cylinders) for one mix, namely 1:1.02:2.22 were made using quarry dust and marble powder as fine aggregate in concrete

Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

Concrete plays the key role and a large quantum of concrete is being utilized in every construction practices. Natural river sand is one of the key ingredients of concrete, is becoming expensive due to excessive cost of transportation from sources

Aug 01, 2017 Aug 01, 2017 Abstract. The replacement of natural fine aggregate by using quarry dust leads to consumption of generated quarry dust, the requirement of land fill area can be reduced and solves the natural sand scarcity problem. The sand availability as a fine aggregate at low cost which needs the reason to search as a alternative material

Engineers have also used quarry dust as total replacement of sand in concrete. Quarry dust concrete for curing age of 28 days resulted higher compressive strength than river sand concrete [5]

Quarry dust as fine aggregate gives better result in compressive strength. The previous study also shows the optimum use of quarry dust with a better strength. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways rather than reducing construction cost. The Erosion of river bank might stopped